Horizontal Oil fired Boiler for industry

Horizontal Oil fired Boiler for industry

Burner and flue installation and electrical installation and the fuel supply system of the burner 1, burner 1) before installation read "burner manual", according to the installation requirements. 2) Burner mounting flange, the middle requirements, to ensure the burner to the horizontal fired boiler for industry flue gas does not leak at the interface. 2, the installation of fuel supply system (see schematic) Note: To prevent a fire caused by generation of static electricity in the fuel tank, the tank should have a good grounding. 1) supply system tank top tank top-feed system suction recommended distance between the back plane and the tubing inside diameter of the oil pump axis, the total length of the suction pipe Hm, m, no greater than DL6-34DL40-75DL100-250Di = 10mmDi = 14mmDi = 16mm0.51.03030401.535452.03535452.540503.0404050 Notes: (1) when there is an elbow or valve on the suction pipe, each of the length of the suction pipe to be minus 0.25m. (2) Di recommended internal diameter suction pipe and return pipe. 2) the distance between the bottom of the tank bottom of the tank supply system supply system pipe inner diameter recommended oil pump axis and a plane, the total length of the suction pipe Hm, m, no greater than DL6-34DL40-75DL100-250Di = 10mmDi = 14mmDi = 16mm1.03030401.535452.03535452.540503.04040504.045 Notes: (1) when there is an elbow or valve on the suction pipe, each of the length of the suction pipe to be minus 0.25m. (2) Di recommended internal diameter suction pipe and return pipe. 3, gas pipe installation requirements Burner gas line itself has been connected, the intake port, the intake pipe bends should be minimized and good sealing performance requirements, to prevent leakage. (Iv) a chimney installation, to prevent leakage, the leakage of smoke, to prevent smoke inhalation chamber. 2, a vertical mounting, a right angle bend bends should be avoided. 3, the top of the chimney must be water-resistant measures. (E) mounting a power switch with electrical connection box 1, the power switch should be considered easy to operate, away from heat, fixation, meet the design requirements. 2, the use of 220V (380V), 50HZ power source, and a ground line. 3, voltage instability in the region use, should be safe regulators. Or affect the normal operation of the combustion engine. 4, the power cord to the electrical box must be connected in strict accordance with the requirements, otherwise, there will be dangerous!

How to improve the thermal efficiency of horizontal fired boiler for industry?

Boiler design efficiency in the engineer design phase, and in general, the actual operation and the initial design thermal efficiency are similar. For example, oil and gas furnace efficiency is greater than 92%, and circulating fluidized bed boiler efficiency is usually higher than 88%. However, boiler efficiency is not fixed. If your equipment is operating at less than design efficiency, then measures can be taken to improve boiler thermal efficiency.

August 10, 2018, Shanghai Industrial Boiler Research Institute Co., Ltd. (hereinafter referred to as the working pot), the National Boiler and Pressure Vessel Standardization Technical Committee of Professional Committee of horizontal fired boiler for industry energy conservation (hereinafter referred to as the Commission) was held in Chengdu, organizational GB / T16508 "shell boilers" revision of the second meeting of the reported revision of the second meeting, the main author of this standard, pot capacity standard Committee appointed sub-standard boiler, the special committee secretariat a total of 10 experts attended the meeting.

Organized by the Shanghai Institute of Industrial Boiler Co., Ltd. Deputy General Manager, committee chairman Wang Shanwu chair. He said the main author of the unit where the standard of support GB / T16508 standard revision of thanks and hope the standard revision process experts complement each other, support each other, the GB / T16508 benchmark revision as the boiler industry standardization work seriously treat, carefully modified. Amended in accordance with the basic principles of the first meeting to determine, in addition to technical support for the "Boiler Safety Technology Supervision" (referred to as "Boiler Rules"), but also take into account the needs of industrial boiler manufacturing enterprises, between consideration and GB / T16507 harmonization. At the same time listen to opinions, to further enrich the standard revision work force, give full play to industry leading products representative firm.

Yung pot boiler Technical Committee Standards Committee Secretary-General Zhang Rui introduced GB / T16507.1 "The first part of the water-tube boilers: General" and GB / T16507.2 "The second part of the water-tube boilers: material" revised draft of the general framework and main content.

Money Fenghua special committee Secretary-General reported on the GB / T16508 since revised "shell boilers" start, the main author of each criterion according to the revised terms of reference and requirements, the completion of the GB / T16508-2013 "shell boilers" since the implementation of the views of summary each sub-standard and contrast "boiler rules" (issued), the sub-standard job descriptions revised terms.

GB / T16508 the sub-standard main author of this according to the relevant sub-standard content and "Boiler Rules" (draft for approval) comparing the results of the relevant sub-standard and harmonized need to modify the content of the standard version 13 implementation of the existing problems and proposed amendments analyze and explain proposed amendments focus on the sub-standard and major amendments envisaged.

Experts on key issues related to the sub-standard for the exchange and discussion to reach a consensus on major revisions of this standard and requirements.

Meeting according to GB / T16508 revision schedule requirements, arranged next phase of work, the following:

1. Revision of Standards fleshed out power to complete the Standards Working Group set up before the end of August;

2. Please carefully review the main author of each standard GB / T16508.1 ~ 16508.8 major amendments description, and recommend changes, submitted to the Shanghai International Industry pot special committee secretariat by August 25;

3.GB/T16508 the sub-standard main author collected the views, modify the preparation of the draft (draft) on the basis of the draft text, submitted to the Shanghai International Industry pot special committee secretariat on September 30.

Center back horizontal fired boiler for industry combustion boiler is preferably small foreign structure, although the two-pass boiler, the heated area is small, but the use of the turbulator charming, the purpose of enhancing the turbulence of the flue gas, disrupt laminar flow boundary wall, reducing the thermal resistance, increasing the heat transfer coefficient, a smaller heating area to achieve the same high thermal efficiency. Lower exhaust gas temperature limit in theory, the exhaust gas temperature can be reduced to very low or even close to the ambient temperature, for maximum thermal efficiency. However, in practice, due to the reduction of the exhaust gas temperature, low temperature corrosion will cause, therefore, the exhaust gas temperature can drop too low, in order to ensure that the wall temperature is higher than the main boiler heating surface flue gas dew point temperature. Therefore, low-temperature corrosion has become a major obstacle to reduce exhaust gas temperature and improve the thermal efficiency of the boiler. Tail auxiliary heating surface increases, further reducing the exhaust gas temperature, fuel gas boiler SZS improve thermal efficiency because the oil, gas type SZS easy to burn the fuel gas boiler air preheater generally not disposed. The economizer means is a common energy, which can be recycled flue gas was able to effectively reduce exhaust gas temperature.

horizontal industry boiler - darbouche-elberskirch.de

Horizontal type steam boiler for sale--. 2019-9-10 · Horizontal steam boilers are very energy efficient due to their long flue gas flow, slow smoke evacuation and high thermal efficiency. horizontal type steam boiler WNS series horizontal fire tube boiler WNS series oil and gas boiler is a fire tube, internally fired, horizontal boiler.

Read More

Coal Boiler, Industrial Boiler, Pulverized Coal Boiler

2020-3-3 · DHL Coal Fired Boiler. DHL Coal Fired Boiler Product Description DHL series boiler is single drum horizontal chain grate bulk boiler. The burning part adopts flake chain grate to match with high-quality auxiliary equipment and perfect automatic control system, which ensures safe, stable and efficient operation of boiler.

Read More

China Oil Gas Fired Industrial 4 Ton Steam Boiler -

China Oil Gas Fired Industrial 4 Ton Steam Boiler, Find details about China Gas Boiler, Oil Boiler from Oil Gas Fired Industrial 4 Ton Steam Boiler - Nanning Miracle Import and Export Trading Co., Ltd.

Read More

Horizontal Heating Diesel Fired Boiler Thermal Hot Oil

Thermal Oil Boiler, Horizontal Oil Boiler, Thermal Oil manufacturer / supplier in China, offering Horizontal Heating Diesel Fired Boiler Thermal Hot Oil Heater Boiler for Industry, Oil Natural Gas Fired Industrial Thermal Oil Heater/Boiler Price, Industrial Horizontal Gas Oil Fired Thermal Fluid Heater/Thermal Oil Boiler and so on.

Read More

heavy oil fired steam boiler hotel_ZOZEN

Automatic & Horizontal Steam Boiler For Rice Mill. 70 years history factory supply diesel oil and city gas fired boiler for hotel heating. US$5,000.00-US$10,000.00 / Set Usage: Textile industry,

Read More

Industrial oil fired boiler manufacturer

horizontal boiler, horizontal oil gas fired boiler Sitong boiler company is devoted to the thermal energy field, manufacturing horizontal boiler, horozontal oil gas fired boiler is the main horizontal boilr type. oil furnace in Ethiopia 40t/h Industrial Gas Boiler Supplier This series

Read More

heavy oil fired steam boiler hotel_ZOZEN

Automatic & Horizontal Steam Boiler For Rice Mill. 70 years history factory supply diesel oil and city gas fired boiler for hotel heating. US$5,000.00-US$10,000.00 / Set Usage: Textile industry,

Read More

Horizontal Type Fire Tube Industrial Oil/Natural Gas

Horizontal Type Fire Tube Industrial Oil/Natural Gas Fired Wns Steam Boiler, US $ 1000 - 10000 / Set, New, New, Hotels, Garment Shops, Building Material Shops, Manufacturing Plant, Machinery Repair Shops, Food & Beverage Factory, Farms, Restaurant, Food Shop, Printing Shops, Construction works, Energy & Mining, Food & Beverage Shops, Video technical support, Online support, Spare parts, Field

Read More

China Horizontal Oil Fired Boiler, Horizontal Oil Fired

China Horizontal Oil Fired Boiler manufacturers - Select 2020 high quality Horizontal Oil Fired Boiler products in best price from certified Chinese Boiler manufacturers, Gas Boiler suppliers, wholesalers and factory on Made-in-China.com

Read More

China 2 Ton Capacity Horizontal Fuel Oil/Gas Steam

Gas Boiler, Steam Boiler, Boiler manufacturer / supplier in China, offering 2 Ton Capacity Horizontal Fuel Oil/Gas Steam Boiler for Textile Industry, Horizontal Double Drums Assembled Coal Fired Hot Water Boiler, Double Drum Travelling Grate Hot Water Heater 2.8MW and so on.

Read More

Horizontal oil-fired boiler (steam, hot water) supplier

Horizontal oil-fired boiler (steam, hot water) ShipParts.com is an e-Procurement platform for marine industry. We are experts in spare parts, equipment and maritime services, providing more business opportunity and simplified trades for ship operators and suppliers.

Read More

heavy oil fired steam boiler hotel_ZOZEN

Automatic & Horizontal Steam Boiler For Rice Mill. 70 years history factory supply diesel oil and city gas fired boiler for hotel heating. US$5,000.00-US$10,000.00 / Set Usage: Textile industry,

Read More

China Oil Gas Fired Industrial 4 Ton Steam Boiler -

China Oil Gas Fired Industrial 4 Ton Steam Boiler, Find details about China Gas Boiler, Oil Boiler from Oil Gas Fired Industrial 4 Ton Steam Boiler - Nanning Miracle Import and Export Trading Co., Ltd.

Read More

heavy oil fired steam boiler hotel_ZOZEN

Automatic & Horizontal Steam Boiler For Rice Mill. 70 years history factory supply diesel oil and city gas fired boiler for hotel heating. US$5,000.00-US$10,000.00 / Set Usage: Textile industry,

Read More

China Horizontal Heating Diesel Fired Boiler Thermal

Horizontal Heating Diesel Fired Boiler Thermal Hot Oil Heater Boiler for Industry picture from Taikang Yinyu Boiler Manufacturing Co., Ltd. view photo of Thermal Oil Boiler, Horizontal Oil Boiler, Thermal Oil.Contact China Suppliers for More Products and Price.

Read More