coal fired steam boiler made in china

coal fired steam boiler made in china

6 tons adjusting a combustion gas coal fired steam boiler made in china, normal combustion boiler three basic aspects of indicators include a uniform supply of the fuel, reasonable ventilation, adjustment the combustion. 1, to maintain the high temperature of the combustion chamber temperature of the upper layer is preferably in the 1100 ~ 1300 ℃, flame orange in color. Flame reddish color indicates that the amount is not enough to the wind, the color white indicates that excessive wind. It should be appropriately adjusted. 2, fuel ash to reduce ash content in the combustibles to be below 10%. 3, reducing the temperature of the boiler flue gas exhaust gas temperature should be controlled below 200 ℃. 4, holding furnace negative excess air boiler is 1.2 to 1.4, by adjusting the balance of the blowers to maintain the furnace pressure is -20 ~ -30Pa. 5, the thermal efficiency of the boiler to improve the thermal efficiency of the boiler should be kept above 60%. II. Combustion Adjustment 1, the amount of fuel to air required for combustion and the amount of a reasonable distribution. Ventilation should first increase the amount of fuel increases, it should first reduce the amount of fuel supply reduced ventilation. 2, the thickness of the seam and seam thickness configuration grate speed is 80 ~ 120mm grate speed at high, middle and low profile configuration of several commonly used methods:. 9a rapid combustion of thin seam b c thick seam in low combustion. 3 thick seam combustion speed, the segment with the wind blowing principle: burn promoting intermediate ends. That is, after the coal into the coal starts to warm up the shutter, fire line front arch, the primary combustion zone, the middle grate to burn the rear grate zone. Normal combustion conditions are: fuel from the coal at the beginning of the fire shutter 300mm, uniform flames, the fire bed formation, at the end of combustion from the end of the grate 300 ~ 500mm. 4. maintain proper furnace temperature to avoid coking. The fire bed to maintain the homogeneous combustion, to avoid burning fire bed obliquely. 6. The residence time of the fuel on the grate in less than 30 minutes.

Jiamusi City, Heilongjiang Province Tangyuan county government to further implement the "Heilongjiang Provincial People's Government of Heilongjiang Province on the issuance of three-year action plan to win the notice of blue sky Wars," the actual situation, carry out a comprehensive rectification for small coal-fired boilers, as follows .

First, the objectives

By the end of 2019 out of the region to build 26 units per hour and 10 tons of steam coal-fired boilers and furnaces tea, operating a stove, food equipment and other coal-fired kiln drying facilities. Out of which 14 coal-fired heating boilers Small units, service three coal-fired boilers, industrial production of small coal-fired boilers nine. By the end of 2020, the region will build small coal-fired boilers cleared number, and completed more than 10 tons of steam per hour of coal-fired small boilers governance standards.

Second, the specific content of execution

1, source control. County-level cities built in the region 35 tons of steam per hour ban on new coal-fired boilers, the rest of 10 tons of steam per hour ban on new coal-fired boilers and below.

2, find out the base. Focus on carefully checking the area of ​​coal-fired boilers case, before the end of May, the completion of the area and the development of coal-fired boilers ledger built-up area, and clearly out of all kinds of coal-fired boilers responsible departments and completion time.

3, held a mobilization meeting. 10 tons of steam per hour, organization and small coal-fired boiler unit, responsible departments held a meeting to clear out of time limits, and invite gas companies, boiler manufacturers, heating companies and small boiler unit for docking, to help provide alternative solutions Program.

4, announced the phase-out plan. Through government websites, issued to small coal-fired boiler unit a variety of ways such as notification, publish small coal-fired boilers out of the list, time frame for completion and telephone hotlines.

5, to carry out law enforcement inspection. Organization of joint law enforcement inspection, supervision of small coal-fired boiler unit to carry out the planned phase-out time frame. Carried out errant time, press the "Heilongjiang Province Air Pollution Prevention Act," the imposition of penalties.

Mill coal fired steam boiler made in chinas to reduce pollution which method 1, leak checking and maintenance of protection: 2 mm steam leakage will cause energy losses of more than 10 tons of coal each year do? When you do not use it, you can turn it off to save energy. For water, steam and compressed air leak survey and routine maintenance, cost very little. 2, the non-contact cooling water in repeated use: Since the non-contact cooling water temperature and the quality is very good, it can be reused for desizing, scouring, rinsing and other processes. Three best source of cooling water is regenerated: sintering machine, a pre-link and compressor systems. The plant water recovery system may be installed, pipes, valves, storage tanks, and control systems. 3, reuse of steam condensate: textile mills require large amounts of saturated water vapor in the dyeing process, wherein a portion of the condensate is converted to its high temperature and purity. Water can be pumped back to the boiler to form a new steam. For those who buy steam from suppliers, or boiler is located away from the dyeing process, the condensate can be used as water washing or desizing. 4, pre-treated wastewater reuse Procedure collected bleaching, mercerizing machine, the water can be reused in other programs, there is no direct discharge of wastewater. 5, hot wash water is recovered from the hot gas in the dyeing process, large amounts of hot water are used to wash. Heat the washing water can be collected by the system plate heat exchanger to preheat the water to be sent to the next washing. 6, pre-screened coal enterprises should introduce screening spiral coal boiler technology to selection of raw materials. It is possible to improve the media tell the good, the bad quality of proportion, to avoid loss of small volumes of coal and coal calorific value. 7, maintaining steam traps traps can help maintain effective delivery of the steam plant. The valve is removed from the steam pipe and prevent further condensation water, so as to avoid heat loss and reduce fuel consumption. 8, pipe insulation pipes, valves and flanges, valves and flanges experience hot waste of resources, reducing efficiency. Steam delivery device insulated to prevent vapor loss is an inexpensive, energy-saving method of .9, the heat recovery boiler chimney smoke at a temperature of 360 deg.] C, and sometimes directly discharged into the atmosphere, there is no heat recovery. In fact, this heat can be used to preheat boiler water, steam or create a new steam system. 10, optimization of compressed air systems consume a large amount of compressed air in many parts of textile machines Mills. These instruments are prone to leakage, particularly in a threaded joint, rubber joints, valves, automatic regulator, the inflatable device and the old gasket. In addition, the use of compressed air pressure is usually based on the maximum pressure setting; reduce this pressure is feasible and would not have any negative impact manufacturing.

Main coal fired steam boiler made in china temperature abnormal phenomenon of how to do 1, main steam temperature anomalies alarm. 2, the rapid variation of the main steam temperature, a secondary damper frequently significantly reducing water operation. 3, starting superheat outlet steam separator above or below normal. 4, if the steam with water, the unit will water shock occurs. 1 reason, the fuel and water supply imbalance, the separator outlet temperature abnormality. 2, coal combustion conditions change or affect, such as excessive load lift; and pulverizing mill administration system abnormality stop; means automatically increase or decrease the failure rate is too large amount of wind and the like. 3, the central flame furnace changes, such as the bottom seal damage, W and inadequate flame downstroke. 4, the control failure by warm water, warm water flow rate reduction is abnormally reduced or increased. 5, feedwater temperature mutation. 6, does not match the wind coal. 7, the secondary combustion heating surface. 8, furnace coking or fouling seriously. 9, heating surface leakage squib. 10, flue gas damper opening degree is not normal. 11, coal sudden change occurred. 12, the uniformity of the powder feeding substantial change occurs. 1 process, failure caused by unit coordinated coal - water ratio should be immediately released coordinate offset, in accordance with the current load demand, with reference to the start of the steam superheat separator, and adjusting the amount of fuel corresponding to the amount of water, with one, two main desuperheating water rapidly steam temperature control in a normal range; when the coal - water ratio should avoid imbalance after coal and water while adjusting; when coal - water ratio is adjusted to further adjust the load after a relatively stable; contact maintenance processing timely. 2, when the water supply system fault condition occurs a significant disturbance furnace should pay attention and automatically coordinated working conditions, so as not to manual intervention, when not working properly coordinated and automated, should be manually adjusted, stable water flow, referring to separation according to the water flow steam superheat, the adjusted amount of fuel, with a secondary spray water rapidly controlling the main steam temperature within the normal range; contact maintenance processing timely. 3, due to rapid changes in load caused by the load change rate should be adjusted; load change caused due to protective operation or the like caused by heat load to be quickly adjusted to maintain the boiler pressure of the main steam stability. 4, by warm water automatic dysregulation, should be appropriate Save warm tone is switched to the manual may be an intermediate point of the feedwater control system be corrected for temperature if necessary, or the feedwater to switch control to manual control, due to lower lifting and lowering the load speed to prevent steam temperature, promptly contact a service process. 5, the boiler furnace cause severe fouling and coking of the main steam temperature anomalies can be corrected by an appropriate degree of superheat outlet steam separator start, adjust, and in a timely manner and the furnace heating surface sootblowing. When the platen superheater sootblowing or superheater outlet temperature is still above normal and a secondary reducing water damper fully open, to check the furnace and the combustion air distribution system is normal, the checking process to reduce still overtemperature unit load. 6, flue gas damper adjusted to an appropriate opening degree. 7, if the bottom seal after losing back to normal immediately. 8, to strengthen the turbine expansion, differential expansion, axial displacement of the shaft vibration and bearing temperature monitoring, if abnormal, the process according to the corresponding regulations. 9, after the above measures, if invalid, should immediately drop the load process. 10, in front of the main steam temperature main steam 50 ℃ drastically reduced within 10 minutes, should an emergency stop.

China Coal Fired Boiler, Coal Fired Boiler

China Coal Fired Boiler manufacturers - Select 2020 high quality Coal Fired Boiler products in best price from certified Chinese Boiler manufacturers, Oil Boiler suppliers, wholesalers and factory on Made-in-China

Read More

China Dzl 4 Coal Fired Steam Boiler Coal Stove - China

Boiler, Steam Boiler, Coal Fired Boiler manufacturer / supplier in China, offering Dzl 4 Coal Fired Steam Boiler Coal Stove, Geomembrane HDPE Liner 1.5mm Smooth Surface Seepage Prevention, Geomembranes Factory Sheets with High-Density Polyethylene and so on.

Read More

China Oil Gas Fired Industrial 4 Ton Steam Boiler -

China Oil Gas Fired Industrial 4 Ton Steam Boiler, Find details about China Gas Boiler, Oil Boiler from Oil Gas Fired Industrial 4 Ton Steam Boiler - Nanning Miracle Import and Export Trading Co., Ltd. Menu On Made-in-China.com

Read More

China Assembled Coal Fired Steam Boiler

Boiler, Steam Boiler, Coal Boiler manufacturer / supplier in China, offering Assembled Coal Fired Steam Boiler Szl10/15/20/25, High Quality Small Scale Gas/ Oil Fired Steam Boiler (0.03-1t/h), Packaged Hot Water Boiler (SZL) and so on.

Read More

China Use of Boiler in Pharmastical Industry - China

China Use of Boiler in Pharmastical Industry, Find details about China Coal Fired Boiler, Coal Boiler from Use of Boiler in Pharmastical Industry - Henan Yuanda Boiler Corporation Ltd. Menu Sign In. Join Free For Buyer. Search Products & Suppliers On Made-in-China.com

Read More

China Boiler manufacturer, Steam Boiler, Coal Fired

Boiler, Steam Boiler, Coal Fired Boiler manufacturer / supplier in China, offering Electric Hot Water Heating Steam Boiler, Thermal Oil Fired Vertical Boiler, Vertical Heat Conduction Oil Boiler and so on.

Read More

China Coal Fired Steam Boiler, Coal Fired Steam Boiler

China Coal Fired Steam Boiler manufacturers - Select 2020 high quality Coal Fired Steam Boiler products in best price from certified Chinese Boiler manufacturers, Industry Boiler suppliers, wholesalers and factory on Made-in-China.com

Read More

China 6t/H Industrial Fire Tube Coal Fired Chain Steam

China 6t/H Industrial Fire Tube Coal Fired Chain Steam Boiler, Find details about China Boiler, Heater from 6t/H Industrial Fire Tube Coal Fired Chain Steam Boiler - Wuxi Zozen Boilers Co., Ltd.

Read More

China Hot Water Steam Boiler for Industry Chain

China Hot Water Steam Boiler for Industry Chain-Grate Coal-Fired, Find details about China Steam Boiler, Industrial Boiler from Hot Water Steam Boiler for Industry Chain-Grate Coal-Fired - Jiangsu Runli Boiler

Read More

Coal Fired Boiler-China Coal Fired Boiler

China Coal Fired Boiler - Select 2020 Coal Fired Boiler products from verified China Coal Fired Boiler manufacturers, suppliers on Made-in-China.com.

Read More

coal fired steam boiler in china - daibgermany.de

Henan Yuanda Boiler Corporation Ltd.,2019-7-8 · Henan Yuanda Boiler Corporation Ltd., was established in 1956. We are professional manufacturer and supplier for coal fired boiler,gas fired boile

Read More

China 12MW Coal Fired/Bagasse Fired - Made-in

Powerplant, Coal Fired, Bagasee Fired manufacturer / supplier in China, offering 12MW Coal Fired/Bagasse Fired Power Plant Including of 72tons Boiler, 12MW Steam Turbine and 12MW Generator Sets, Two-Semi-Trailer Mobile Substations (230/ 66/20) Kv with One 66 Kv Gis Incoming and One 20 Kv Gis Incoming Metal Enclosure Without Truck., 72.5kv 40mva Mobile Substation and so on.

Read More

China Grate Boiler Coal Fired Steam Boiler For Sale

2019-8-10· found in 1945, Now mainly produce gas & oil fired boiler, Biomass fired boiler, Coal chain grate boiler, CFB power plant boiler, Industrial autoclave. With 70 year experience, is a leading steam and hot water boiler manufacturer in China.

Read More

China Industrial Packaged Coal Fired Travelling Grate

China Industrial Packaged Coal Fired Travelling Grate Steam Boiler1-35tph, Find details about China Boiler, Packed Boiler from Industrial Packaged Coal Fired Travelling Grate Steam Boiler1-35tph - QINGDAO HAMMER INDUSTRIES CO., LTD.

Read More

China Coal Steam Boiler, China Coal Steam Boiler

China Coal Steam Boiler - Select 2020 high quality China Coal Steam Boiler products in best price from certified Chinese Gas Steam Boiler manufacturers, Industrial Coal Boiler suppliers, wholesalers and factory on Made-in-China.com

Read More